Category: Case Studies

Problems Now Dropping cooling tower efficiency Scale build-up Why Use Cooling Towers? Cooling towers are used to reduce the temperature of a liquid, water, by bringing it into contact with an air stream where a small portion of the water Read More …

Problems Now Increased disposal costs Excess soap purchases High maintenance costs Why Recycle Floor Scrubber Water? Recycling and reusing floor scrubber water can lower your maintenance costs. The used floor scrubber water contains a concentration of soap. When the floor Read More …

What happens to the Quench Water? As polymer quench water is used, its inherent properties of heat transfer ability and finishing quality begin to degrade. This degradation in quench quality occurs because the quench water is gradually being contaminated with Read More …

Problems Now Excess wear and tear on equipment Leaking seals Sticking valves Blocked orifices and ports Tramp oil “New” water glycol hydraulic oil contamination What Happens During The Water Glycol Hydraulic Oil Process? Water Glycol Hydraulic Oil has many critical Read More …

Problems Now Tramp oil Short fluid life Replacement cost Disposal cost Unacceptable finished product What Happens to Parts Washer Fluids? As your parts washer fluid is used and reused it begins to accumulate tramp oil and contaminants that accumulate in Read More …

What Happens To Coolant? Coolant does not “break down” per se. However, the machining process does introduce contaminants into the coolant. In addition, coolant provides an environment for bacteria, resulting in the “rotten eggs” smell of used coolant. Ever increasing Read More …

Problems Now Dropping vacuum pump efficiency Sludge build-up in your vacuum pump oil Improper oil in your vacuum pump Decreased vapor pressure Excess moisture Pump failure Why Dedicated Filtration? Vacuum pump oil filtration is inexpensive compared to the cost of Read More …

The practice of blending used motor oil into diesel fuel has been around for many years. The main advantage is the oil never leaves your direct control, so you don’t have to worry about cleanup liability due to improper handling Read More …

Problems Now High diesel fuel costs Quality of “New” diesel fuel Contaminants in your oil Contaminants in your engine Diesel Fuel Concerns: Water and particulate are continually being formed or deposited in all fuel storage tanks. The condensation process goes Read More …

Problems Now Frequent maintenance intervals Engine/transmission performance Vehicle operating costs What Happens To Engine/Transmission Oil? Having clean oil in your vehicle at all times would be the perfect solution to extending engine/transmission life. However, the normal operation of the vehicle Read More …